2004 Volkswagen Passat Tdi - Manual Trans, Bsm Delete! on 2040-cars
Winston-Salem, North Carolina, United States
|
These cars were only offered with an extremely problematic automatic transmission. It wasn't a question of *if* it would fail, it was *when*. No more worries with this one. Professionally swapped to a manual transmission using nothing but OEM parts/hardware/wiring. I went to great lengths to ensure it was done right. You have to push the clutch in for the car to start. The reverse lights and cruise control both work perfectly as well. I am a Volkswagen factory certified master technician, with a passion for TDI's. Everything was done right. If you're shopping for one of these cars, keep in mind the cost to replace both the automatic transmission and the BSM (balance shaft module) will run you over $7000. You'll never have to worry about either of those expensive repairs with this car.
Now, she runs and drives like a dream. Perfect cruiser while getting that great diesel mileage. And with a mere 137,000 miles, she's got alot of life left in her. The silver exterior paint is in great condition, and the interior is even better. I'd challenge you to find a nicer one, but chances are, you'll not find another one available like this. The number of these cars that have been converted to manual transmission is very small, and they don't pop up for sale often. As for maintenance, she obviously has a brand new clutch kit and flywheel installed when the transmission was swapped. Fresh oil change (with Liqui-Moly 505.01 spec oil and OEM filter). Timing belt was just done @ 135K miles along with deleting that also problematic balance shaft module (BSM). All the filters were replaced less than a year ago. Tires have less than 5K miles on them (Bridgestones, no maypops). 4 small issues with the car. First, the antenna base gasket is missing (this doesn't seal against moisture, it's purely cosmetic - available on ebay for ~$10). Secondly, the little information center in the middle of the instrument cluster starts to fade out a bit when it's really hot outside (you can see in the picture of the instrument cluster). Third - the headlights are hazing over a bit. No big surprise there really, happens to most cars these days. Plenty of cheap "headlight restoration" services these days available almost anywhere. And finally, the transmission is from a V6 Passat. Works flawlessly of course, but runs a little higher in the RPM range on the highway. Currently, she'll run about 3000RPM at 78mph, and I average 41.5mpg at that speed (recently took her on a 500 mile trip to the dragon and back). As I understand, the european TDI transmission would run about 2300-2400rpms at that speed, so the difference is negligible. A european transmission and installation can be negotiated into the sale if desired, but the price will go up accordingly. I have purchased one, but didn't feel it was worth the work with the way she drives now. I'm perfectly happy with her. As she sits now, she really needs nothing but a new driver - and she wouldn't even need that, but I'm ready for a new boat so this has to go. She is being driven daily so mileage will go up slightly. I will help with shipping in any way possible if you desire, but I encourage you to come see her in person, and drive her home. |
Volkswagen Passat for Sale
Black auto fwd navigation glass sunroof heated front seats satellite radio
2005 volkswagen passat glx sedan 4-door 2.8l $5,700.00(US $5,700.00)
2013 volkswagen passat s cruise ctrl alloy wheels 15k texas direct auto(US $16,980.00)
2005 volkwagen passat gls tdi wagon
2009 volkswagon passat wagon(US $12,000.00)
Tdi sel prem diesel 2.0l nav side air bag system multi-function steering wheel
Auto Services in North Carolina
Wilkinson Automotive ★★★★★
West Jefferson Chevrolet Buick Gmc ★★★★★
Virginia Avenue Auto & Wrecker ★★★★★
Troutman Tire & Auto Inc ★★★★★
Toyota Specialist The ★★★★★
Tony`s Foreign Car Center ★★★★★
Auto blog
Volkswagen Passat gets Wolfsburg Edition, priced from $23,495*
Tue, 23 Apr 2013Volkswagen has just announced a new Passat Wolfsburg Edition, which slots between the base S and mid-grade SE trims in terms of content and price. The automaker has not released any official photos of the car as of this writing (aside from the badge shot you see here, of course), but the Wolfsburg Passat will be visually set apart from the rest by a unique set of 16-inch alloy wheels.
The big host of upgrades for the Wolfsburg Edition are found inside, where buyers will enjoy standard amenities like leatherette seats (with bun-warmers on the front chairs), a power driver's seat, satellite radio and a media interface with iPod connectivity. Of course, this comes on top of the already standard Passat features like Bluetooth and auto on/off headlamps. The Wolfsburg Passat will only be available with the 2.5-liter five-cylinder engine and a six-speed automatic transmission.
Look for the 2013 Wolfsburg Edition Passat to hit dealerships in the very near future, priced from $23,495, *not including $795 for destination. Have a look below for Volkswagen's official press blast.
VW confirms Golf GTD diesel coming to US for 2016
Wed, 03 Jul 2013Part of the Volkswagen Golf recipe that has helped the car sell more than 30 million units in just under 40 years is the number of variants in which the hatchback is offered. Building on that range here in the US, Automotive News is reporting that we will finally be getting the sporty Golf GTD, likely as a 2016 model. It's the GTD, you'll recall, that crosses the performance abilities of the venerable GTI with a powerful and fuel-efficient diesel engine.
After speaking with Andreas Valbuena, Volkswagen product manager for the Golf, AN not only says that the GTD will for sale in the US in a couple years, it also estimates a baseline price of around $27,000, which would place it between the current pricing for the GTI and the Golf R. The GTD is launching in Europe this summer, but we won't be getting the seventh-generation Golf in the US for another year. The news about the performance diesel model isn't entirely unexpected - VW officials have been hinting at it for at least a year now, going so far as to import a sixth-generation model for media test drives on US soil, a task we happily took them up on last year.
The Mk VII GTD uses VW's 2.0-liter TDI engine with output increased to 184 horsepower and 280 pound-feet of torque, allowing the car to sprint to 60 miles per hour in about seven seconds while returning more than 40 mpg in highway driving. We can't wait.
Tanner Foust checks out his new VW Beetle GRC rally car
Thu, 11 Sep 2014Racing driver and Top Gear USA host Tanner Foust is a very busy guy. After all, he's competing in rounds of both Global Rallycross series and FIA World Rallycross Championship, not to mention his TV duties. However, we probably shouldn't feel too sorry for him, because his job puts him behind the wheel of some truly crazy machinery.
Case in point is his latest ride in Global Rallycross - the Volkswagen Beetle GRC. The German company claims that this all-wheel drive Bug makes around 540 horsepower from its 1.6-liter turbocharged four-cylinder and can shoot to 60 in under 2 seconds. Plus, if this video is any indication, this Volkswagen sounds like a machine gun when throwing revs at idle, and it can do some wonderfully easy four-wheel drifts.
Previously, Foust was driving a VW Polo for Andretti Autosport in GRC, but the team unveiled the look of the Beetle GRC at the Chicago Auto Show. Now, Foust is finally getting to show off his new office to the public, and like VW's tagline for the new car claims, it's way hotter than Herbie.