2011 Volkswagen Golf Tdi Hatchback 4-door, Malone Tune Pd Exhaust Ecs Suspension on 2040-cars

Auto blog

VW going turbo-only in 3 to 4 years

This really was a matter of when, rather than if. Volkswagen will apparently be the first manufacturer to phase out naturally aspirated engines in favor of turbocharging its full slate. VW is kind of responsible for ushering in this push towards small-displacement, turbocharged engines that's taken the industry by storm. When it dropped its direct-injection, 2.0-liter turbo in the 2005 GTI it demonstrated that strapping an iron long to an engine can enhance the powertrain as a whole. VW made fuel economy gains, while also giving a linear, non-laggy turbo experience that it has replicated, model-after-model, to this day.
Speaking with The Detroit News, Volkswagen's executive Vice President of Group Quality, Marc Trahan, told the paper that, "We only have one normally aspirated gas engine, and when we go to the next generation vehicle that it's in, it will be replaced. So three, four years maximum."
Really, it's hard to get teary-eyed about either of these engines going away. VW has access to smaller powerplants that could easily match the performance of the 2.5 five-cylinder and the 3.6 V6, while gobbling up less fuel and providing a better driving experience. What we are sad about is that a similar statement about the extinction of NA engines came from the Vice President of Powertrain Engineering at Ford, Joe Bakaj. We'd certainly get teary-eyed over a world without Ford's excellent 5.0-liter V8.

VW announces recall of 26,000 2014 models with 1.8T engines

Volkswagen has followed up on a stop-sale order from earlier this month, announcing a voluntarily recall of 26,400 vehicles that are powered by the brand's 1.8-liter, turbocharged four-cylinder engine. The new mill replaced the despised 2.5-liter five-cylinder in the Jetta, Passat, Beetle and Beetle Convertible last year. Weirdly, though, of the 26,452 units covered in the recall, only 1,655 are customer vehicles.
According to VW, the affected models were built between February 1 and April 6 of this year, and feature bad O-ring seals in the transmission oil cooler. Apparently, the faulty O-rings could cause a fluid leak, as they won't seal between the oil cooler and transmission. VW is blaming a material change from a supplier for the problem.
There have been no fires, injuries, accidents or fatalities relating to this issue, which VW will be fixing free of charge. Customers will need to report to dealers to have the O-rings replaced.

VW Chattanooga plant very close to UAW representation

After months of fighting from both sides, it looks like the Volkswagen factory in Chattanooga, TN, might unionize under the United Auto Workers after all. According to a letter acquired by The Associated Press, VW and the UAW reportedly struck a deal last spring where the union agreed to stop its challenge of the organization vote with the National Labor Relations Board to help clear the way for the CrossBlue to be produced in Tennessee. In exchange, the automaker would recognize the UAW at the plant. Leaders of the Local 42 at the facility reportedly signed the letter.
It seems that such an agreement would clear the way for the factory to unionize after months of dispute. According to The Detroit News, under Tennessee law, workers aren't required to join the organization. Although, that might not be a problem. As of a few months ago, Local 42 already claimed to have signed around 700 of the plant's roughly 1,500 workers.
Controversy has constantly swirled around the possible unionization at the Chattanooga plant. The UAW held its official decision in February and lost 712 to 626. However, there were allegations of intense political pressure to make sure the ballot failed. A later report also found that VW was offered $300 million in incentives well before the vote to make sure things progressed to the "satisfaction of the State of Tennessee," but the deal was later retracted. In July, the UAW opened Local 42 on the campus in hopes of signing up a majority of the workforce by volunteering to be a part of it.