** Limited ** Double Cab ** Trd ** Auto ** Clean Mb Trade In ** on 2040-cars

Auto blog

Toyota and Lexus recalling 235,000 hybrid CUVs and sedans over separate issues

When it rains, it pours. Toyota has announced a pair of separate but voluntary North America recalls covering approximately 235,000 vehicles built between 2006 and 2011. The larger of the two recalls targets Toyota's hybridized crossovers, the Lexus RX400h and Toyota Highlander Hybrid. 133,000 units, including 2006-2010 Highlander and 2006-2008 RX crossovers are covered in the campaign. The other recall affects 102,000 IS350 sedans, IS350C convertibles and GS350 sedans built between 2006 and 2011.
With the CUVs, the faults in the parallel circuits of the transistors can cause heat damage in the inverter assembly, triggering an abundance of warning lamps and sending the vehicle into limp mode. The Lexus sedans are being recalled due to loose bolts on the variable valve timing controller. Detected by unusual underhood sounds on startup, the issue can cause the engine to stop while driving. The inverter issue is also triggering similar recalls in Japan and Europe.
At the moment, it's unclear if any of these issues have caused any crashes or injuries. Toyota says it plans to notify owners of the recall via snail mail. Additional information for owners can be found on the recall sites for Toyota and Lexus or by calling Toyota's customer service line, at 1-800-331-4331. Scroll down for the complete recall notice from Toyota.

Toyota U2 urban utility concept inspired by Maker Faire [w/video]

There's a quiet revolution happening in US cities. People want to mix an urban lifestyle with a connection to nature and appreciation for craftsmanship. The result of all of this is folks pursuing things as varied as urban farming, home brewing and the whole maker movement. Toyota thinks it has the perfect concept for these intrepid customers with its new Urban Utility concept that it is debuting during a panel discussion hosted by Make: magazine in San Francisco and debuting publicly on September 20 at the World Maker Faire in New York City.
The Urban Utility concept can best be described as a modern take on the old panel van. Designers from Toyota's Calty Design Research center in California interviewed Maker Faire participants to find out what its users want from a novel vehicle like this. "Toyota saw an opportunity for a new approach to an urban vehicle based on increasing re-urbanization of our cities and urban drivers' desire for flexibility, fun and maneuverability," said Kevin Hunter president of Calty.
On the outside, the Urban Utility doesn't really scream for attention. It's meant to meet users "desire for greater utility but a smaller vehicle footprint," according to the release, but the shape is still very much a van. The designers do try to lend it some panache with the LED headlights up front and checker board side panels. It's really more about utility than looks, though, because the roof can roll back for taller loads, the rear glass retracts into the tailgate, and the whole rear can fold down as a ramp to load stuff more easily into the cabin. Toyota isn't talking about a powertrain yet but claims that the underbody is also especially durable for a long life in the big city.

Subaru to stop building Camry for Toyota in the US

It was back in 2007 that Subaru of Indiana Automotive, under contract from Subaru minority shareholder Toyota, built the first Toyota Camry at its plant in Lafayette, Indiana. Rumblings of the end of that contract work have been around for a while, as Subaru talked of expanding capacity to build more units and add a line for the Impreza, and Toyota talked of moving Camry production to its Georgetown, KY plant. The news was official internally last November when SIA Executive Vice President Tom Easterday told the Louisville Courier-Journal that Camry production would end. Now, Automotive News reports that both automakers have admitted publicly that the end will come in 2016.
SIA currently has a 170,000-unit capacity devoted to the home-brand Legacy and Outback models, while a $400-million expansion increases that to 300,000 units to prepare the facility for Impreza production in two years. Freeing up the 100,000 units of production devoted to the Camry means a 400,000-unit capability, which is far more than Subaru needs at the moment, but the Toyota exit will allow it to expand any way it sees fit. Subaru has said it will absorb the workers on the Camry line and no jobs will be lost, the mayor of Lafayette saying the development could change the timetable for the expansion.