2002 Toyota Highlander Limited Sport Utility 4-door 3.0l on 2040-cars

Auto blog

Toyota and Lexus recalling 235,000 hybrid CUVs and sedans over separate issues

When it rains, it pours. Toyota has announced a pair of separate but voluntary North America recalls covering approximately 235,000 vehicles built between 2006 and 2011. The larger of the two recalls targets Toyota's hybridized crossovers, the Lexus RX400h and Toyota Highlander Hybrid. 133,000 units, including 2006-2010 Highlander and 2006-2008 RX crossovers are covered in the campaign. The other recall affects 102,000 IS350 sedans, IS350C convertibles and GS350 sedans built between 2006 and 2011.
With the CUVs, the faults in the parallel circuits of the transistors can cause heat damage in the inverter assembly, triggering an abundance of warning lamps and sending the vehicle into limp mode. The Lexus sedans are being recalled due to loose bolts on the variable valve timing controller. Detected by unusual underhood sounds on startup, the issue can cause the engine to stop while driving. The inverter issue is also triggering similar recalls in Japan and Europe.
At the moment, it's unclear if any of these issues have caused any crashes or injuries. Toyota says it plans to notify owners of the recall via snail mail. Additional information for owners can be found on the recall sites for Toyota and Lexus or by calling Toyota's customer service line, at 1-800-331-4331. Scroll down for the complete recall notice from Toyota.

Toyota pondering high-performance GT86 hybrid?

From what Autocar has to say, Toyota has even more plans for the GT86 beyond the convertible concept we just saw at the Geneva Motor Show. Along with a planned midcycle facelift, Toyota is reportedly looking at how to pack some extra ponies under the coupe's hood, and while there has already been a lot of talk about superchargers and turbochargers, it sounds like a performance-boosting hybrid system could also be in the works.
Talking to Toyota chief engineer Tetsuya Tada, Autocar has learned that the automaker is considering an electrical motor assist for the sporty coupe to improve performance without harming fuel economy. In attempting to keep weight - and, presumably, costs - down, the article mentions the use of a system closer to what Honda uses for its Integrated Motor Assist rather than a full Hybrid Synergy Drive system used in current Toyota hybrids. Tada says the added weight of the system could be offset by weight reduction, while aerodynamic changes and a lower center of gravity could improve the car's handling.
No word yet on whether a mild hybrid system would find its way to North America's Scion FR-S - let alone its Subaru BRZ twin - but the thought is certainly an intriguing one.

Toyota mini doc chronicles Tundra towing Space Shuttle Endeavor

Toyota has worked up a quick video detailing the brand's involvement in the transportation of the Space Shuttle Endeavour last year. As you may recollect, the California Science Center ran into a hitch when it came to moving Endeavour from LAX to its new home. While most of the route would be covered by a robotically controlled transporter, one portion of the route directed the shuttle over an interstate. Unfortunately, the bridge across wasn't designed to stand up to the weight of the shuttle and its motorized sled.
The Science Center would have to remove Endeavour from its transporter and place it on a lighter, non-motorized sled. That's where longtime Science Center sponsor Toyota came in. As it turns out, the automaker had to prove to the California Science Center that a Tundra could actually tow the massive shuttle, so engineers put on a little demonstration with a stock truck pulling the equivalent weight over flat ground for the same distance. Once the Science Center was satisfied that the Tundra could pull it off, the move was green lit and the rest is history. Check out the short documentary below for yourself.