2000 Saturn Sl Sl Manual on 2040-cars

Auto blog

GM recalling another 2.7 million vehicles in five separate campaigns

The recalls keep rolling in from General Motors, evidently keen to avoid repeating the mistakes of the ignition-switch debacle and clean house. This time they're all coming at once, with five separate recalls announced together covering approximately 2.7 million vehicles.
The largest of the five actions involves over 2.4 million units of the previous-generation Chevrolet Malibu and Malibu Maxx, Pontiac G6 and Saturn Aura in order to fix brake light wiring harness, which have been found to be susceptible to corrosion. The recall is separate from the 56k Aura sedans which GM recently recalled over faulty shift cables, not to mention the previous massive recall of 1.3 million vehicles - some of them the same models - but appears to have resulted from the National Highway Traffic Safety Administration investigation that started with the G6 almost a year ago.
The second-largest campaign involves the 2014 Chevy Malibu, specifically those fitted with GM's 2.5-liter engine and stop/start system, approximately 140,000 examples of which has been found to have problematic brakes. The issue does not appear to be connected to the recall of 8k Malibu and Buick LaCrosse sedans (also involving brake woes) which we reported upon last week. Four crashes have been reported in such models, but GM admits it's not yet clear if the problem was a contributing factor in the accidents.

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

Recalled Saturn Ion facing separate federal safety probe

General Motors may be staring down another recall campaign for one of its models already embroiled in its high-profile ignition recall. The 2003-2007 Saturn Ion is already among the 1.6-million vehicles being recalled for faulty ignition switches, and now new light is being shed on a National Highway Traffic Safety Administration investigation over 2004-2007 models centering on a loss of power steering.
The government safety regulator has received 846 complaints about the problem and claims that GM has had 3,489 reports of failure. Of those cases, there have been 16 accidents and 2 injuries reported, according to Automotive News. While NHTSA has been conducting an investigation since September 2011, no recall has been issued yet.
The inquiry's length was brought to light by an organization called the National Legal and Policy Center that alleges GM and NHTSA have known about the problem but are delaying a recall. It has sent a letter to CEO Mary Barra asking "to recall Saturn Ions for the model years 2004 through 2007 without further delay." The letter in question is available in full on the group's website.