Jeep Wrangler Cummins 4bt on 2040-cars

Auto blog

Dodge and Jeep recalling 895k SUVs for possibility of headliner fires

Dodge and Jeep are announcing recalls of a total of 895,000 Durango and Grand Cherokee models worldwide from the 2011 through 2014 model years. There's a possibility that the wiring in the sun visor can short circuit and cause a fire. It specifically affects vehicles built between January 5, 2010, and December 11, 2013, and there are approximately 651,000 of them in the US, 45,700 in Canada, 23,000 in Mexico and 175,000 outside of North America.
Screws that fasten the sunvisor to the headliner may pierce wires in the visor, if the part has been removed or serviced, potentially causing a fire risk. If the wires short circuit, they could overheat and potentially combust. The automakers report three injuries caused by this defect, and according to the investigation by the National Highway Traffic Safety Administration, "there may be a total of 52 unique fire incidents."
To fix the problem, Dodge and Jeep will inspect the vehicles for suspect wiring, and all of the models, whether damaged or not, will get a new sun visor spacer with a wire guide to stop the possibility of short circuits. According to the automakers' announcement, "this condition is not present in vehicles which have not had the headliner or vanity mirror serviced." They will notify affected owners, and repairs will begin in August.

Chrysler recalling 644k more Dodge Durango and Jeep Grand Cherokee SUVs over brakes

Early last month, we reported on Chrysler issuing a preemptive, proactive recall for about 25,000 units of the Jeep Grand Cherokee and Dodge Durango. The issue revolved around a brake system that wasn't causing any actual problems, but delivered an unsatisfactory brake feel, so Auburn Hills called in a good 25,000 of SUVs around the world, including 18,700 in the United States.
Now Chrysler, having apparently determined that the brake problem on its sport utes is actually much bigger than it initially realized, has drastically broadened the scope of the recall. As a result, the National Highway Traffic Safety Administration has issued a recall for precisely 655,354 examples of the Grand Cherokee and Durango, covering the 2011 through 2014 model years. In addition, Chrysler is recalling 42,380 units in Canada, 21,376 in Mexico and 159,685 overseas.
The problem which Chrysler found revolves around the brake booster, whose center shell has been found to be subject to corrosion, allowing water to get into the brake system. That water in turn could freeze, preventing the brakes from working as well as expected.

NHTSA closes book on Jeep 'trailer hitch' recall after all

After much debating and hand-wringing, the National Highway Traffic Safety Administration now says it has "no reservations" with Chrysler's plan to recall certain Jeep Liberty and Grand Cherokee models over concerns that their fuel tanks, which are located behind the rear axle, could rupture or leak in the event of a rear impact. The longstanding argument between the two entities saw Chrysler openly defy the Feds after a request to recall 2.7 million units back in June.
Chrysler's "voluntary campaign" will instead see it recall 1.56-million 1993-2004 model year Grand Cherokee SUVs, along with 2002-2007 Liberty models. Affected vehicles will get a trailer hitch installed free of charge, which Chrysler says will provide an additional degree of protection for the fuel tanks in the event of a crash. Jeeps with Mopar-branded hitches or hitches that were installed at the factory aren't affected by this recall.
Chrysler's argument throughout this battle has been that the Jeeps in question are no more susceptible to fires than comparable vehicles from the same time period, a position that NHTSA has seemingly arrived at as well. "Those vehicles performed at a rate similar to their peers. That is the keystone analysis as to whether something poses an unreasonable risk to safety," said outgoing NHTSA boss David Strickland during an interview with the The Associated Press.