on 2040-cars

Auto blog

2016 Jeep Wrangler to ditch solid axles to save weight?

Hey, Jeep fans. If you think the idea of a funky-looking, car-based Cherokee revival is offensive, have a listen to what might be in store for the next-gen Jeep Wrangler. Automotive News is reporting that as Jeep develops the 2016 Wrangler, weight reduction is a crucial target, and the Wrangler's rugged solid axles could be sacrificed in the name of better fuel economy.
We've already heard the next Wrangler will go on a serious diet using aluminum body panels and an air suspension system, so the idea of a four-wheel independent suspension setup for this OG SUV isn't all that surprising. Besides, it's not like an independent suspension would limit the Wrangler's off-road abilities - just check out the Hummer H1. In fact, it might be the aftermarket parts companies - not Wrangler enthusiasts - who would be most disappointed by such a drastic suspension change, as the article states that the Wrangler's solid axles and coil-link suspension make it the most popular SUV for customization.
There are probably still a couple years before we'll start hearing any concrete details about the 2016 Wrangler, at which time it will be interesting to see how stricter fuel economy and crash safety regulations have been balanced with traditional Wrangler cues like its removable doors and roof and folding windshield. Let us know in the comments below if a Wrangler sans solid axles is any less of a Wrangler.

NHTSA closes probes on Jeep Grand Cherokee, Ford Freestar and Mercury Monterey

The Detroit News reports the National Highway Traffic Safety Administration has officially closed its investigations into 2012 Jeep Grand Cherokee, 2004-2005 Ford Freestar and Mercury Monterey models. The separate probes found no issues that pose safety concerns. NHTSA began investigating certain Grand Cherokee SUVs over complaints that power steering hoses could detach during operation, thereby increasing the risk of a vehicle fire. Of the 24 reports of failure, none alleged smoke or fire in the engine bay, and Chrysler has since modified the power steering cooler assembly to reduce the likelihood of the failure.
Meanwhile, certain Ford Freestar and Mercury Monterey vehicles garnered a government probe after receiving complaints that the models were equipped with faulty scissor jacks. The agency had received six reports of the jacks failing or causing injuries, including one incident that resulted in a fatality. But NHTSA says the jack failure rate is similar to those found in other vehicles. In those six cases, the government agency found the jacks were being used for something other than changing a tire, and investigators could not determine whether the emergency brake was set or the rear tires were properly chocked.

Dodge and Jeep recalling 895k SUVs for possibility of headliner fires

Dodge and Jeep are announcing recalls of a total of 895,000 Durango and Grand Cherokee models worldwide from the 2011 through 2014 model years. There's a possibility that the wiring in the sun visor can short circuit and cause a fire. It specifically affects vehicles built between January 5, 2010, and December 11, 2013, and there are approximately 651,000 of them in the US, 45,700 in Canada, 23,000 in Mexico and 175,000 outside of North America.
Screws that fasten the sunvisor to the headliner may pierce wires in the visor, if the part has been removed or serviced, potentially causing a fire risk. If the wires short circuit, they could overheat and potentially combust. The automakers report three injuries caused by this defect, and according to the investigation by the National Highway Traffic Safety Administration, "there may be a total of 52 unique fire incidents."
To fix the problem, Dodge and Jeep will inspect the vehicles for suspect wiring, and all of the models, whether damaged or not, will get a new sun visor spacer with a wire guide to stop the possibility of short circuits. According to the automakers' announcement, "this condition is not present in vehicles which have not had the headliner or vanity mirror serviced." They will notify affected owners, and repairs will begin in August.