2002 Jeep Grand Cherokee Limited 4x4 One Owner Rebuilt on 2040-cars

Auto blog

Chrysler recalling 630k Jeep models worldwide

Despite its refusal to recall 2.7 million Jeep Grand Cherokee and Liberty models this week over a gas tank fire risk, Chrysler will be recalling 630,000 Jeep Compass (pictured), Patriot and Wrangler vehicles around the globe for a pair of entirely different reasons.
The affected Compass and Patriot models are all from the 2010 to 2012 model years - 254,000 in the United States, 45,400 in Canada and 109,000 elsewhere in the world. In these models, a software error may result in the late deployment of the side airbags and seatbelt tensioners. In the event of a crash, failure of these systems could result in more serious injuries for the vehicle's occupants.
Jeep's go-anywhere Wrangler also faces a separate recall due to power steering fluid lines that can possibly wear a hole in the transmission oil cooler line. According to Chrysler, the vehicles could then leak fluid, possibly damaging the transmissions. Roughly 221,100 Wrangler models are being recalled because of this issue, all of which are fitted with Jeep's 3.6-liter Pentastar V6 engine. In the US, 181,000 vehicles are affected, with an additional 18,400 in Canada and 21,700 additional units worldwide. A Chrysler spokesperson said that no crashes or injuries have been reported with either case, according to the Associated Press.

NHTSA still mulling crash tests for recalled Jeeps

Well, no one should ever accuse the government of not giving things plenty of thought. The National Highway Traffic Safety Administration is still debating whether it will retest any of the 1.56 million 1992 to 1998 Grand Cherokees and 2002 to 2007 Libertys that were part of a recall regarding fires after rear-end collisions. And yes, this debate has been going on for over a month. In other news...
The recall dustup started in early June, when Chrysler took the unusual position of refusing a recall request from NHTSA regarding placement of the fuel tank on the effected vehicles. NHTSA said a collision could cause a fire, a position Chrysler took issue with. Extensive negotiations ensued, with Chrysler agreeing to fit certain Jeeps with trailer hitches, which it said would provide some protection to fuel tanks mounted behind the rear axle in the event of a collision.
Part of the issue rests with the amount of data that needs to be processed, according to The Detroit News. NHTSA administrator David Strickland said during a Washington Auto Press Association meeting, "There's a lot of data and Chrysler is being very cooperative in giving us more data." Until that information has been sorted, it looks like re-testing will still be up for debate.

NHTSA upgrading Jeep Grand Cherokee, Dodge Durango headliner fire probe

The National Highway Traffic Safety Administration investigation into headliner fires experienced by a small number of Jeep Grand Cherokee and Dodge Durango owners has been upgraded to an engineering analysis, the step before the initiation of a recall. In August last year the investigation began with 146,000 Grand Cherokees from 2012 after three complaints were received, but a report on Edmunds says it has been expanded to include 593,299 vehicles covering the 2011-2013 model years for the Jeep and the Dodge Durango, which uses the same headliner assembly, because of possibly 52 incidents of fire.
In some of those incidents drivers have reported a burning odor, smoke or open flames that were contained to the headliner or migrated to another area of the passenger compartment. The culprit has apparently been found: NHTSA blaming an electrical short in the sun visor vanity light wiring, which is routed under the headliner and held in place by three screws. Chrysler began its own probe into the issue when it was first reported and is still looking into the situation while, "fully supporting the National Highway Traffic Safety Administration's investigation."