1990 Ford Taurus Sho Sedan 4-door 3.0l on 2040-cars

Auto blog

NHTSA closes investigations into Ford Taurus, Hyundai Santa Fe

Ford and Hyundai are out from under the scrutinizing eyes of the National Highway Traffic Safety Administration after the government agency said it was closing investigations against both automakers over vehicle safety concerns.
Ford was being investigated for reported damaged speed control cables on Ford Taurus (shown above) and Mercury Sable models, both built between 2000 and 2003. Vehicles with the company's Duratec engines allegedly failed to allow owners to brake as expected. Owners lodged 100 complaints and were involved in five accidents, according to NHTSA records. The American automaker responded to the reports, and on June 21 of this year, said that it would inspect and repair all affected vehicles, regardless of the mileage.
Hyundai was under investigation for a reported loose fastener on the steering shaft of its 2011 Santa Fe (shown in the gallery below). After NHTSA launched its inquiry, the Korean automaker responded with its own investigation that yielded four affected vehicles. Following the inspection of 680 vehicles at its assembly plant, Hyundai said the issue was due to employee error and that no further defects have been found.

Ford and Chrysler reducing summer plant shutdowns

Most domestic automaker assembly plants traditionally take a couple of weeks off during the summer. The shutdowns give each plant time for much needed repairs and maintenance, and in some cases, help better align production with demand. Not this year, though, as demand for many models is outstripping what Ford, Chrysler and General Motors plants can produce.
Ford has announced that it will shorten its annual summer shutdown for most North American plants from two weeks to one. The shorter shutdown will increase the carmaker's annual North American production by 40,000 units on top of the 200,000 extra units that it was already planning to produce this year versus last. Automotive News reports that Ford produced 2.8 million vehicles on this continent in 2012, and that output this year has already increased 13 percent through April.
Chrysler, meanwhile, is also operating at full tilt and plans to run some plants through the summer with no shutdown at all. Those not getting a break include Jefferson North where the Jeep Grand Cherokee and Dodge Durango are assembled, Toledo North that will assemble the new Cherokee, and Conner Avenue, home of SRT Viper production. Other assembly plants will be down for a single week, while all of Chrysler's engine and transmission plants except one in Indiana will continue operating with no shutdown this summer.

Ford settles class action suit over defective Navistar diesel engines

The 2003 Ford F-Series Super Duty (shown above) introduced the 6.0-liter Power Stroke diesel supplied by Navistar, and while that is an engine Ford would love to forget, it's now one step closer to putting that particular problem behind it. Automotive News is reporting that Ford has settled a class-action lawsuit brought on by problems with this engine that started right out of the gate and ultimately broke up the 30-year relationship between Ford and Navistar.
Owners and lessees of 2003-2007 Super Duty trucks and E-Series vans equipped with the 6.0-liter Power Stroke are eligible for deductible reimbursements of between $50 and $200 from the original five-year/100,000-mile engine warranty, while Ford is paying out as much as $825 for out-of-warranty engine repairs. These repairs may include the exhaust gas recirculation (EGR) cooler, EGR valve, oil cooler, fuel injectors and turbocharger, but are only covered if the components failed before six years or 135,000 miles.
In total, Ford has agreed to pay about 50 percent of the value of the repairs and deductibles paid by its customers who submit a claim before the end of this year, and $150,000 is going to the 16 named plaintiffs in the case; Navistar was not included in the lawsuit.