2011 Ford Taurus Sel on 2040-cars

Auto blog

Ford Transit production fires up, American Pickers among first takers

Not long ago, the History Channel showed a seemingly unending stream of World War II documentaries, but it made a switch a few years ago to include an increasing mix of 'reality' programming. American Pickers was one of the early attempts at this new formula, with cameras following hosts Mike Wolfe and Frank Fritz around the country in a Mercedes-Benz Sprinter as they tracked down collectibles and "rusty gold" for their Iowa shop, Antique Archeology. The show has since gone on to become one of the channel's most popular programs.
Starting in the new episode airing tonight, the affable hosts will swap their Benz for a 2015 Ford Transit, a nicely timed bit of marketing to coincide with the launch of the model's assembly at the Blue Oval's Kansas City Assembly Plant, which also kicks off this week. Ford is touting 2,000 new jobs created as part of its $1.1-billion investment in the plant.
No strangers to product placement, the guys from American Pickers say their switch away from the Sprinter is because they wanted to balance cargo capacity and fuel economy to make the most of their cross-country jaunts. They opted for the largest Transit available with a long wheelbase, extended body and high roof, giving them 487 cubic feet of cargo room. Hauling power comes from a 3.2-liter, five-cylinder diesel engine with 190 horsepower and 346 pound-feet of torque and a six-speed automatic transmission with rear-wheel drive. Fittingly, the van wears the same Antique Archaeology logo over white paint as their old Sprinter.

2015 Ford Mustang already under recall, but just 53 units

Ford has issued a small - but significant - recall for one of its spotlight cars: the 2015 Mustang.
The recall affects just 53 cars, with 50 in the United States and three in Canada. Ford said the passenger side safety belt buckle tension sensor may not have been calibrated properly by the supplier. This could lead to "misclassification" of the passenger seat occupant, and could cause the airbag to deploy improperly.
A Ford spokesperson didn't immediately respond to a request for comment. In a statement, the automaker said it is not aware of any accidents or injuries, and dealers will replace the buckle assembly at no cost to customers. The cars affected were built at Flat Rock Assembly Plant in Michigan from Aug. 18 to Oct. 2.

Ford, Samsung shack up to bring regen braking to non-hybrid models [w/video]

Ford must be desperate to get itself ready for the beach this summer because it is really trying to get into shape. Shortly after unveiling the Lightweight Concept that cut the weight of a Fusion down to that of a Fiesta, it's now the rest of the line's turn for improvement. The company is wrapping up a 10-year research project aimed at developing next-gen automotive batteries to improve efficiency.
Ford claims that 70 percent of its lineup will have stop/start tech by 2017. The key to this massive proliferation is its new dual-battery system that combines a lithium-ion battery with a lead-acid one and regenerative braking. The setup works by harvesting braking energy and converting it to electricity. When the vehicle stops, the engine shuts off, but the Li-ion battery has enough juice to keep the accessories running. The engine starts up again as drivers take their foot off the brake. The layout would mean less wasted gas while idling. It's already available on Ford hybrids and is somewhat similar to the i-Eloop capacitor-based system from Mazda.
The bigger challenge is tuning the regenerative braking right. While hybrid drivers may be a little more adventurous, when it comes to getting a hang of regen braking, conventional buyers might not be so open-minded. The systems have a tendency to be a little grabby at first and then taper off at very low speeds. Ford needs to make sure it's just right to avoid turning off buyers.