2004 Ford F-450 Xl 4 X 4 Dump Truck W/ Dejena Body And Snow Plow on 2040-cars

Auto blog

F-150 just the start of Ford's aluminum plans

Not only have we been told that the 2015 Ford F-150 is tougher, more durable and up to 700 pounds lighter than the current truck, Ford COO Mark Fields said it's also "CAFE-positive." That means, for the first time in the history of corporate average fuel economy standards, the F-150 would be a positive contributor on Ford's CAFE balance sheet instead of being a vehicle it needs to counterbalance with frugal offerings.
Fields' comments made at the Detroit Auto Show were among quotes from other Ford execs that confirmed the carmaker will be using aluminum for more of its vehicles. CEO Alan Mulally said it would "proliferate across our lineup," with speculation being that we'll see it applied to crossover and sport utility models first, since they'll benefit the most. Even gaining the massive scale of using aluminum on the world's best selling vehicle for its first effort - on average, the company sells two times as many F-150s in a single day as Land Rover sells of its aluminum Range Rover in a month - Ford will be looking to further spread the cost of its five-year development investment in aluminum technology. And that should mean better handling and fuel economy for those of us who don't need to wear hardhats at the office.

Ford F-150 bumps Camry from top of Cars.com American Made Index

With July 4th just around the corner, what better time could there be for Cars.com to announce that the Ford F-150 is the Most American car of 2013? This may be especially true since it was the Toyota Camry, a car produced by a company based in Japan, that had held the top spot from 2009 to 2012.
Cars.com compiles its Most American list by considering the amount of parts each vehicle uses that come from America, where it's final assembly takes place and how many units per year are sold. "While the assembly point and domestic parts content of the F-150 didn't change from 2012-2013, vehicle sales are responsible for bumping the F-150 to the top spot," according to Patrick Olsen, Editor-in-Chief of Cars.com.
As far as automakers go (as opposed to individual models), Toyota retains the top spot it held in 2012, with General Motors, Chrysler, Ford and Honda (in that order) rounding out the list. The motivation behind this list each year, according to Olsen, is "to help car shoppers understand that 'American-Made' extends beyond just the Detroit three" and because "a study we conducted in 2012 indicated that 25 percent of shoppers surveyed preferred to buy American."

NHTSA closes Ford F-150 EcoBoost acceleration probe

Typically when we report on the findings of an investigation from the National Highway Traffic Safety Administration, it's because the government body has discovered a safety issue and prescribed a recall. In this case, however, NHTSA has closed an investigation into a reported performance deficit without ever getting to the recall stage.
The issue revolves around the Ford F-150 - specifically those equipped with the 3.5-liter EcoBoost engine - of which some 360,000 were built in the 2011, 2012 and 2013 model years. After receiving an initial 95 complaints, NHTSA opened an investigation last May - almost a year ago - into the reported issue of reduced engine power under hard acceleration. The agency has since received a total of 525 such complaints, and Ford itself reported receiving over 4,000.
Together, NHTSA and Ford determined that the problem resulted from cylinders misfiring, an issue itself stemming from water getting into the charge air cooler (CAC) mated to the turbochargers. In particularly humid or rainy conditions, water was found to get into the CAC, causing some of the cylinders to misfire, which in turn triggered the ECU to disable those cylinders in order to protect the catalytic converter from damage.